IC660BBD021
IC660BBD021
IC660BBD021
IC660BBD021
在東風4型機車上裝有電動機油泵和燃油泵，在每次起動前需延時45s~60s 供機油和燃油，供機油是為了防止在柴油機停機時間較長時，其各運動部件拉傷，而提供的燃油則是為柴油機點火建立燃油壓力。在供機油過程中，起動滑油泵運轉時間不能過長，否則不利于蓄電池的保養。在起動過程中，起動電機轉動和燃油泵向氣缸內供油為同步控制。油壓建立以前，起動電機不可以停轉。
起動柴油機必須解決3 個問題：（1）燃油的供給；（2）運動部件的潤滑；（3）蓄電池向起動電機供電，QD 帶動柴油機轉動。在整個起動過程中，對起動電機和噴油泵供油齒條的控制，都是通過起動接觸器（Q C）來實現的。
這種控制方法存在如下缺陷：
a.操縱人員必須通過主觀判斷起動完成與否來控制柴油機起動，每次起動都需要耳聽發火聲，眼睛觀察機油壓力表的變化；
b.向氣缸內供油過早，在柴油機低速轉動時，噴油器的噴油質量很差，將降低氣缸內的溫度，拖延點火轉速，導致起動能量耗高，排煙量大，甚至爆燃；
c. 在柴油機氣缸內已經點火后，蓄電池繼續向起動電機供電，造成蓄電池的放電量大；
d. 如果由于某種原因柴油機不能正常點火，將出現起動接觸器燒死的情況，并且蓄電池虧能增大。
2 柴油機起動過程的編程設計
針對目前柴油機起動過程中的缺陷和不足，可以將其起動過程按時間展開，進行編程控制，采用PCC 實現檢測和控制環節。
柴油機的起動過程大致可分為4 個階段，準備、柴油機被驅動轉動、點火和建立油壓穩定運轉。準備階段主要是預供機油和燃油。東風4型機車采用45s 延時控制燃油泵和機油泵運轉。實現起動前預先向管路供油。根據起動過程的不同階段，結合前面柴油機起動過程中的問題，可逐步解決。
在東風4型機車上裝有電動機油泵和燃油泵，在每次起動前需延時45s~60s 供機油和燃油，供機油是為了防止在柴油機停機時間較長時，其各運動部件拉傷，而提供的燃油則是為柴油機點火建立燃油壓力。在供機油過程中，起動滑油泵運轉時間不能過長，否則不利于蓄電池的保養。在起動過程中，起動電機轉動和燃油泵向氣缸內供油為同步控制。油壓建立以前，起動電機不可以停轉。
起動柴油機必須解決3 個問題：（1）燃油的供給；（2）運動部件的潤滑；（3）蓄電池向起動電機供電，QD 帶動柴油機轉動。在整個起動過程中，對起動電機和噴油泵供油齒條的控制，都是通過起動接觸器（Q C）來實現的。
這種控制方法存在如下缺陷：
a.操縱人員必須通過主觀判斷起動完成與否來控制柴油機起動，每次起動都需要耳聽發火聲，眼睛觀察機油壓力表的變化；
b.向氣缸內供油過早，在柴油機低速轉動時，噴油器的噴油質量很差，將降低氣缸內的溫度，拖延點火轉速，導致起動能量耗高，排煙量大，甚至爆燃；
c. 在柴油機氣缸內已經點火后，蓄電池繼續向起動電機供電，造成蓄電池的放電量大；
d. 如果由于某種原因柴油機不能正常點火，將出現起動接觸器燒死的情況，并且蓄電池虧能增大。
2 柴油機起動過程的編程設計
針對目前柴油機起動過程中的缺陷和不足，可以將其起動過程按時間展開，進行編程控制，采用PCC 實現檢測和控制環節。
柴油機的起動過程大致可分為4 個階段，準備、柴油機被驅動轉動、點火和建立油壓穩定運轉。準備階段主要是預供機油和燃油。東風4型機車采用45s 延時控制燃油泵和機油泵運轉。實現起動前預先向管路供油。根據起動過程的不同階段，結合前面柴油機起動過程中的問題，可逐步解決。
BALDOR Assy PUMP Motor W/viton 34H609W315G1
NEC 10.5" LCD Display NL6448BC33-59
PALL Fairy Ring Filter KC-GDF6406E
WARRENDER PVDF WET END, WE5002/ICS
MKS MANOMETER, TYPE 128, 128AA-00010B
Humphrey Solenoid Bank ST053101CJ-02
3 way/port valve
Allied Motion / Emoteq Leadscrew Assy, E3-1000-250-I
FRABA ABSOLUTE ANGLE ENCODER 5813-4096-FBA1D?P03PG
Eurotherm AC Servo Motor, PGH07
BIORAD 8" Cassette, QS600, 013-5363-3
MKS MANOMETER, 0-10, 1/4 VCR, 124AA
EUROTHERM AMPSTACK, 70 AMP, 208 AC, AS-1
TIMNTA INPUT FILTER 3L+N+E, FMAD-0937-8010
EUROTHERM CONTROLLER, 461082
NT INTERNATIONAL FLOW THRU PRESSURE TRANSDUCER
Futurestar FLOWMETER 5 GPM 1/2" Anolog Odyssey
Master Interface PCB w/optional Arcom 123626
Lambda LND X 152 12-15 Volt Regulated Power Supply 2.5A
APPLIED MATERIALS QUARTZ COVER 125mm POLY, 0200-10044
APPLIED MATERIALS Ring, top, 125 mm flat, 0200-00157
COORS Tek, SEMI WAFER. CEL 8.62, 41120-87756-010
Entegris Replacement element kit and wire guards 213-75
Entegris 3/4" PFA Hand Valve KC-201-41-01
BALDOR Industrial Motor MI6B 91751373-03
AMD Liquid Conductivity Assy. FT811-05-001 Rev. A
Applied Materials 0020-82818 APERTURE PLATE - AMI
Applied Materials 0020-86734 CLAMP, FILAMENT L/H
Applied Materials 0020-86733 CLAMP, FILAMENT R/H
Applied Materials 0020-31147
KLA Instruments KLA R1F Assembly 710-652840-20 Rev E1
Absolute Filter Assembly 2T-39516093-Z28?5
Absolute Filter Assembly 2T-69516093-Z28?4
VARITRONICS LABEL AND SIGN MAKER
Applied Materials Shield, Lower, 8", 0200-25077
Applied Materials Ring, Quartz, Pedestal, 0200-09217
TESTO MODEL 490 CALIBRATOR
LEYBOLD STRAIGHT THRU VALVE, 29923
LEYBOLD TR ANGLE VALVE, WITH ACTUATOR, 29823
LEYBOLD INLINE VALVE, VIP-025
Air Products Cable Cabinet Display 2103-0395
MOTOR SERVO W/US DIGITAL ENCODER THERM BHO2302-B11HE
BALLUFF LINEAR TRANSDUCER 305MM, BTL-S-P1-M0305-?P-KA05
Applied Materials 0020-98947 ELECTRODE, EH1 (SIC) - AMI
Applied Materials 0040-97144 STRAP CONNECTOR F.G.
YASKAWA AC BRUSHLESS MOTOR SERVO, SGMP-01U314CM
EMOTEQ BRUSHLESS DC SERVO MOTOR HS01001-A02-HGE
YASKAWA BRUSHLESS AC SERVO MOTOR, SGMP-01U314CM
FLUOROWARE PNEUMATIC MANIFOLD VALVE, 1/2", 710-416X2
ION SYSTEMS FLOW BAR CONTROLLER, 100VAC, 1/4 A
LAM PC Assembly 28-8875-037
LAM/ONTRAK Power Supply 40-0075-007
KOBOLD INSTRUMENTS FLOWMETER, SV-10
CTE CHEM TEC / SEMITOOL ANALOG FLOWMETER,
Flowline Level Transmitter KC-LA15-5001
Semittol Optical Motor Encoder W/Brake
Semitool / Hathaway Motor Encoder W/Brake
APPLIED MATERIALS INC. LINER, SIDE, P19500 AMI
LAM ASSEMBLY GAP HEATING
RTS SPARES LLC ASSEMBLY. SHUTTER, A65
LAM PLATE, BAFFLE, LOWER, 8.3 (4428)
APPLIED MATERIALS COVER, QUARTZ 6" POLY, 0200-00043
DAIFUKU CO., LTD UNIT (S/R) YAGI OPTI, TRANSMIT
Entegris 2 WAY VALVE 3/8 X 1/4 ORIFICE 201-87-01
APPLIED MATERIALSAPERTU?RE, SILICON CARBIDE, EHO AMI
POLY FLOW ENGINEERING MOTOR, GEAR, 3RPM, 1/50TH HP
AMETEK GAS INDICATING PRESSURE SWITCH IPS-200-LA
LAM 9600 Ceramic Consumables Rings
Applied Materials 0010-99166 MOVING CLIP ASSEMBLY
SCANDIALOGIC CONTROLLER, SCM750-1
SEMITOOL DIGITAL FLOWMETER FT0-4A1YS-LHA-1
Pacific Scientific Motor STF3624-5604-61?-56C
Hayward Actuator for drain Valves KC-PHS15
Applied Ceramics RING XL CLAMP SILICON, 91-01394A
Applied Ceramics VALVE SLIT INSERT QUARTZ 91-01680A500
FLOWMETER 5-20 GPM 3/4 FLR ENDS 72056-85
MILLIPORE .05 MICRON QUICK CHANGE FILTER, QCDZATXTH
Applied Materials 0020-82813 ELECTRODE, APERTURE, EHO-
Ultrasonic Ranging Proximity Sensor RPS 300
MILLIPORE WAFERGARD T-LINE GAS FILTER WGGB 12S02
PARKER REGULATOR BACK PRESSURE, BR-3-1168-2
AUTOMOTION MOTOR CONTROLLER ALC1500 MAGNUM
CUTLER-HAMMER INDUSTRIAL CIRCUIT BREAKER, EHD3020L
PARKER REGULATOR DI 0-60PSI 1/2 FNTP PTFE, PR-3-1118-2
Integrated Power Designs Power Supply SRW-115 4005
DATA INSTRUMENTS DIGITAL FLOWMETER, 410500-9022/AFL?AS
NET MERCURY VALVE, PNEUMATIC ACTUATED- GAS
TOKYO ELECTRON SENSOR, ATM PS-10V 760 TORR, TEF
Sensor Technics Pressure Transducer 839-607828/SQ00?503
AP Tech Regulator AP1910SM/889-60?6950
MKS Manometer ABS 124AA-00100BB
Proportion Air PA 70905-27
MAC SOLENOID VALVE 3-WAY 20 STAGE CIRCUIT BAR L 202
Lambda 500W Power Supply FE050048-RA
Integrated Power Designs Power Supply REL-110-4006
Applied Materials 0020-82821
Applied Materials 0020-83583 SHIELD GUIDE TUBE 9500XR
SENSARRAY 6" TEST WAFER PART 1501B-6-0001
MAGNETEK LOADER, 10-349222-01
Futurestar Rotameter-Flowm?eter
Air Products N2 Trickle Purge Plumbing 216730
Control Concepts AC Noise Filter KC-IE-110
Applied Materials, ESC ASSEMBLY 125 MM, 0090-00091
Setra Pressure Transducer 2251100PGD41106
APPLIED MATERIALS SHADOW RING 0200-00156
NT INTERNATIONAL FLOW THRU PRESSURE TRANSDUCER
ASTI Flow Sensor 20 L/min, 3/4 FLR
Entegris 4/2" PFA Hand Valve 201-42-01
APPLIED MATERIALS SCREEN SLIDE ENTRY 9500XR - AMI
DNS ELECTRONICS ARM, 1H (2) - 80A- SCRUBBER
Intelligent Motion Systems (IMS) Microstepper and Index
Pentagon Tech Pedestal, Quartz, Pinless, Q15-0217
BIMBA MOTOR ASSEMBLY WITH HIGH TORQUE PLATING 0G70-S YG
Arcom, I/O Board, w/ standoffs AIM104-RELAY8/I?N8
Air Products AP2 LCD Display 809-607057
Tescom Pressure Regulator 44-2262-242-010
LFE INSTRUMENTS TEMPERATURE CONTROLLER 955241C-1190
Flextech, Cabinet Controller, 2103-0391
EUROTHERM DRIVE, B5261101BZ
Entegris 1/4" Auto valve w/check valve KC-202-69-01
APPLIED MATERIALS DC POWER SUPPLY, 01-81913-00
Saint Gobain Door Seal 480150091
AP2 Solenoid Bank 16V VV3Q11-ULB97019?3-16
Air Products Solenoid Digi. output board 809-607699
NT INTERNATIONAL ACID TRANSDUCER 1/2 FLR 0-60PSI
NT INTERNATIONAL PRESSURE TRANSDUCER FLOW THRU 3/4"
SMC APX16-Point Solenoid Bank 13V VV3Q11-ULB97019?4-13
SMC APX16-Point Solenoid Bank 10V VV3Q11-ULB97019?4-10
Granville-Phill?ips 275 Convectron Gauge For N2
MRC PCB, STEPCONTI/F, 884-55-000
Cable, Sensor, PT-100 85939
Saint Gobain Door Seal 480150089
Nikon PCB 4S018-210A
APPLIED MATERIALS PEDESTAL ASSEMBLY, 0010-09574
Cutler Hammer Industrial Circuit Breaker
Yaskawa Servo Motor, SG25TA-PE01A1
ASTI Flow Sensor 10 L/min, 1/2 FLR
Blue White Flowmeter, 0.2-2.0 gpm, Model F-500
Futurestar Odyssey Flowmeter 1 pm, 1/4 FLR
Futurestar Odyssey Flowmeter 1.75-5 lpm, 3/8 FLR
Futurestar Odyssey Flowmeter 5-250cc, 1/4 FLR
Yaskawa AC Servo Motor, Brushless with Brake
MKS INSTRUMENTS BARATRON, 1 TORR, 370HA
EMOTEQ CORP MOTOR ASSY PADDLE ACTUATING HS01001-A02-HGE
PATLITE SIGNAL TOWER, SL-402V
APPLIED CERAMICS, CERAMIC PLATE, 200MM, 716-028721-281
Cherry Electric exhaust vane switch 1491-3144
ASYS CONTROLLER, 10052885
FURON 1/2", 2 way Valve, DIBPOL8PC
FURON OMNISEAL 3/16" X 12.375" 70887-23
INSERT, INNER, MULTI-CHARGER/B?EAM TRAP MULTI-CHARGED
HATHAWAY/EMOTEQ MOTOR LIFT/TILT, BH02301A F04HBE
Micronix, I/0 board, PV-1648 Rev.3
Arcom, I/0 board, AIM104-ANALOG-I?/O
Air Products Comm. Controller board 287-607240
WESCO DISCONNECT SWITCH, NZM7-200-NA
Yaskawa AC Servo Motor, SGMP-01U314M
BIORAD 5" Cassette, QS600, 013-5363-1
APPLIED MATERIALS FINGER LONG HOLLOW GRIPPER -AMI (SLO
FURON 1/2", 2 way Valve, WB-2W8P-C
LEYBOLD STRAIGHT THRU VALVE, 428902
Air Products LCD Display 1730-7203
在線咨詢 
在線客服：0571-87774297
