沸石轉輪濃縮+RTO |
![]() |
價格: 元(人民幣) | 產地:上海 |
最少起訂量:1套 | 發貨地:上海 | |
上架時間:2019-04-04 15:32:50 | 瀏覽量:173 | |
上海安居樂環保科技股份有限公司
![]() |
||
經營模式:生產加工 | 公司類型:股份有限公司 | |
所屬行業:其他環保分類 | 主要客戶:工廠 | |
![]() ![]() |
聯系人:熊經理 (小姐) | 手機:13816803170 |
電話: |
傳真: |
郵箱:xiongli@anjule.com | 地址:上海市奉賢區青偉路188號 |
沸石濃縮轉輪被分為吸附區、脫附區、冷卻區三個功能區,沸石分子篩轉輪在各個功能區域內連續運轉。 在吸附區:廢氣通過前置的過濾器后,送至沸石分子篩轉輪的吸附區。在吸附區(吸附區面積為S1 )有機廢氣中的VOCs被沸石分子篩吸附,未被吸附的廢氣在吸附風機的帶動下,直接排人煙囪達標排放。在脫附區:沸石轉輪上吸附的VOCs,在脫附區(脫附區面積為S2 ) 被高溫逆向脫附、濃縮,脫附溫度約200oC:,濃縮倍數一般為5 ~ 25倍。濃縮倍數:n = (S1 x V1)/(S2 xV2 ) ,其中 S1/S2 = 10:1 ,V1/V2 = ( 0.5 ~ 2.5 )。脫附氣在脫附風機的帶動下進人RTO焚化系統。 在冷卻區:為保證高的吸附效率,需對高溫脫附后的轉輪進行冷卻。冷卻空氣冷卻轉輪吸附材后自身被預熱,作為脫附氣的源氣,再與來自RTO燃燒室來的高溫凈化氣換熱,溫度提升至180 ~ 200oC 后逆向進人轉輪脫附區進行高溫脫附。 沸石分子篩轉輪的設計參數見表2 。
沸石分子篩轉輪設備整體密閉,污染源主要為沸石分子篩更換產生的廢沸石材料,但根據工程實際案例運營情況,吸附材料一般壽命在5 年以上。
蓄熱氧化爐 采用三床式RTO。RTO蓄熱式氧化爐,是在高溫下將可燃廢氣氧化成對應的氧化物和水,從而凈化廢氣,并回收廢氣分解時所釋放出來的熱量,廢氣分解效率達到99% 以上,熱回收效率達到95% 以上。主體結構由燃燒室、陶瓷填料床和切換閥等組成。根據客戶實際需求,選擇不同的熱能回收方式和切換閥方式。建設單位將調漆、噴涂廢氣收集后,經過濾除漆霧、吸附濃縮后,引人RTO進行焚燒處置。經焚燒處理后的廢氣通過換熱后,廢氣高空排放。RTO可實現廢氣安全、穩定地焚燒,在工作過程中需定期鼓人新鮮空氣用以維持燃燒,空氣中的氮在高溫條件下氧化會產生熱力型氮氧化物。根據文獻記載,熱力型氮氧化物的生成量主要取決于溫度,在相同條件下,氮氧化物的生成量隨溫度增高而增大,當溫度低于1350oC時,幾乎不生成熱力型氮氧化物,建設項目RTO工作溫度約為760 ~ 850oC,在此情況下,熱力氧化器氮氧化物的產生量極少,因此建設項目廢氣處理系統內不設氮氧化物處理裝置。 蓄熱式焚燒爐的工作原理:將有機廢氣預熱至760oC以上,在燃燒室加熱升溫至800oC左右,使廢氣中的碳、氫、氧元素氧化分解成為無害的CO2和H2O ;氧化時的高溫氣體的熱量被特制的陶瓷蓄熱體“貯存”起來,用于預熱新進人的有機廢氣。從而節省升溫所需要的料消耗,降低運行成本。 蓄熱焚燒爐英文名為“Regenerative Thermal Oxidizer”,故簡稱為“RTO”,它通常由多個蓄熱室組成。在設備運行前運用點燒器加溫把有機廢氣加熱到800℃以上,從而使廢氣中的VOC在氧化室氧化分解成二氧化碳和水。氧化產生的高溫氣體流經特制熱陶瓷,使蓄熱陶瓷升溫而“蓄熱”;此“蓄熱”用于預熱后續進入的有機廢氣,從而節省用于廢氣升溫的燃料;蓄熱室,“放熱立即引入已處理合格的潔凈煙氣的一部分對該蓄熱室進行清掃。每個蓄熱室依次經歷蓄熱放熱清掃等程序,周而復始,連續工作。
安居樂VOC沸石轉輪濃縮GRTO裝置簡介: Zeolite Rotary Concentrator Wheel+ GRTO:
How to treat low concentration with large air flow waste stream? Shanghai Anjule has patent designed solutions with the zeolite concentrators to reduce the air flow of the pollutant and concentrate the VOCs before the RTO treatment. Improve the removal efficiency, reduce the operating cost while meeting the regulations. This is a leading technologies in treating VOCs and HAP.
The process flow for zeolite rotary concentrator wheel+ RTO (RCO)
Anjule technology can be applied to work with the process specifications. For example, emission from coating industrial has the characteristic of high air volume: the waste gas was sent to the G-vortex column to remove particulate. After the dehumidifier process, the waste gas was sent to a specially designed filter before entering the rotary concentrator for VOCs adsorption. The removal efficiency can achieve VOC removal efficiency above 90%. A system fan was installed to release the cleaned air, which is in compliance with the regulations. The air stream then transfer to the RTO for further treatment.
1. Rotary entrance with G-vortex column Anjule G-vortex column has a unique vortex structure, purify and remove the paint organic substance from gas. The advantage: 1. Avoid the blockage of the packing media; reduce the operating cost; and achieve high removal efficiency of VOC substance. Minimize the accumulation of the paint substance0n the rotary and at a result prevent fire hazard.
2. Advance rotary device
Aujule has set up a laboratory and an engineering center for the design of the exhaust gas VOC treatment. The rotary wheels are imported from Japan; the VOC compounds removal rate are measured in a laboratory to ensure the successful treatment for the environmental projects. The advantage of our rotary concentrator: small size, convenience, low pressure lost and work continuously to concentrate low VOC concentration waste gas. The rotary processed gas has a high concentration of VOC with less volume and therefore reduce the amount of the waste gas for the RTO treatment.
3. Safety guarantee Patent designed of Anjule GRTO has put the fire, explosions and other safety factors into fully consideration. The operation of the GRTO is steady, safe and reliable.
4. Advance Technology GRTO control system equipped with software and hardware interlocks, through temperature, pressure responses, the system reacts immediately to the safety control of the system. Effectively,protect the safety of the system . RTO control system uses PLC, installed inside of the control panels; equipped with flame intensity detector, temperature controllers, alarm, reset,0n and off switch, emergency stop, and a recorder; RTO system works seamlessly with the production line without interfering to the existing production.
5. The low operating cost advantage Lower operating cost can be achieved with high VOC concentration in the waste stream. Using a rotary concentrator to reduce the volume of the waste gas is a feasible way in decreasing the cost.
2017年日本雅馬哈電子樂器天津有限公司上了一套VOCs 治理設備。設備通過環保驗收后,安全、穩定運行。廢氣源為噴漆,線路板、印刷廢氣,風量140000m3/h,濃度進口681mg/m3,出口為6.44mg/m3,凈化效率99%,遠遠低于天津市DB12/524-2016《工業企業揮發性有機物排放控制標準》。憑借設備的優秀性能,該項目拿到了天津市環境保護專項補貼獎金叁佰多萬元。 沸石轉輪的生產產商無法相信VOCs 治理設備三年時間還能保持穩定高效的凈化效率,所以專門找人去天津雅馬哈公司測試,并把樣品拿回東京本部論證。 雅馬哈GRTO設備如圖 天津雅馬哈工廠沸石轉輪+GRTO蓄熱式焚燒爐 日本住友天津公司也使用了GRTO蓄熱式焚燒處理設備。日本住友天津公司的廢氣主要橡膠硫化廢氣,處理風量:10000m3/h;廢氣成分:顆粒物,油霧,氨氣、硫化物、苯系物、非甲烷總烴等。在使用GRTO后,日本住友先后兩次委托獨立的第三方監測公司分別進行了兩天6頻次的監測,監測數據都滿足了合同約定出口VOCs小于1 mg/m3,且遠低于天津地方標準60mg/m3。日本本部專門來人和天津工廠先后采用了手持設備連續一周進行在線監測,數據都達到合同約定標準。隨后,廣州住友和合肥住友分別又上了4套該設備。
沸石轉輪吸附濃縮+ RTO工藝先采用轉輪吸附濃縮,降低了 RTO設備廢氣處理量,使得RTO規模變小,降低了設備投資費用;盡管有機廢氣濃度比較低,但經濃縮后,有機廢氣濃度達到自持濃度以上,所以RTO除了首次開機預熱需要消耗天然氣(RTO輔助燃料)外,其他時間RTO輔助加熱系統無需開啟,同時脫附風熱源來自于有機廢氣氧化釋放的熱能,系統運行費用低。沸石轉輪濃縮一RTO凈化系統采用PLC全自動化控制并配備液晶觸摸顯示屏。控制程序監視所有控制器、驅動器、壓力開關、壓力變送器、熱電偶、限位開關、生產線連鎖信號和儀表連鎖信號。如發生任何異常,人機界面就會顯示故障信息,然后通過程序控制采取適當動作,確保系統的安全。 |
版權聲明:以上所展示的信息由會員自行提供,內容的真實性、準確性和合法性由發布會員負責。機電之家對此不承擔任何責任。 友情提醒:為規避購買風險,建議您在購買相關產品前務必確認供應商資質及產品質量。 |
機電之家網 - 機電行業權威網絡宣傳媒體
關于我們 | 聯系我們 | 廣告合作 | 付款方式 | 使用幫助 | 會員助手 | 免費鏈接Copyright 2011 jdzj.com All Rights Reserved技術支持:杭州濱興科技有限公司
銷售熱線:0571-28292387 在線客服:0571-87774297
展會合作/友情連接:0571-87774298
網站服務咨詢:0571-28292385
投訴熱線:400-6680-889(分機7)
網站經營許可證:浙B2-20080178